Caterpillar engine CID diagnostic codes
Caterpillar engine error codes, troubleshooting, diagnostics, error removal.
1 Nozzle cylinder 1
2 Cylinder No. 2 injector
3 Cylinder No. 3 injector
4 Cylinder No. 4 injector
5 Cylinder No. 5 injector
6 Cylinder No. 6 nozzle
7 Cylinder No. 7 nozzle
8 Cylinder No. 8 injector
9 Cylinder No. 9 injector
10 Cylinder No. 10 injector
11 Cylinder No. 11 injector
12 Cylinder No. 12 injector
13 Cylinder No. 13 injector
14 Cylinder No. 14 injector
15 Cylinder No. 15 injector
16 Cylinder No. 16 injector
17 Fuel shut-off valve
18 Fuel control valve
19 Accelerator bypass valve
20 Fuel injection advance angle change device
21 Engine position sensor
22 Fuel injection advance sensor
23 Rack drive
24 Rail Position Sensor
27 Variable geometry turbocharger actuator No. 1
28 Variable geometry turbocharger actuator No. 2
41 ECU power supply (electronic control unit) 8 V DC
42 Injector activation valve
70 Parking brake contact sensor
71 Idling stop timer
75 Steering hydraulic circuit oil temperature sensor
81 Pressure sensor at the inlet of the foreign particle trap
82 Air start system pressure sensor
84 Travel speed sensor
91 Accelerator pedal position sensor (gas)
94 Fuel pressure sensor
95 Differential pressure sensor on the fuel filter
96 Fuel level sensor
98 Engine oil level sensor
99 Differential pressure sensor on the engine oil filter
100 Engine oil pressure sensor
101 crankcase gas pressure sensor
102 Turbo boost pressure sensor
104 Turbocharger oil pressure sensor
105 intake manifold temperature sensor
106 Inlet air pressure sensor
109 Coolant pressure sensor at the exit of the engine
110 engine coolant temperature sensor
111 coolant level sensor engine
112 Coolant filter differential pressure sensor engine
124 Gearbox oil level
126 Differential pressure sensor on the gearbox oil filter
127 Transmission oil pressure sensor
138 Low traction mode switch
139 electromagnet feed tip back
140 tip forward solenoid
141 Economy switch
142 door position sensor for cleaning the radiator
143 Contact pressure sensor control unit neutral
144 reverse horn relay
145 12 V power supply circuit
146 Hitch mode switch
147 Lockup clutch pressure sensor
148 Pressure sensor in the hydraulic system of the stroke
149 Three-position electromagnet of the stabilization system of the working tool when moving
150 Tamper speed sensor
151 tamper electromagnet
152 Diagnostic lamp of the steering system
153 speed sensor right drive motor
154 speed sensor left drive motor
155 electromagnet of inclusion of a course
156 electromagnet of the right turn in reverse (electronic scoreboard)
157 electromagnet of the left turn in reverse (electronic scoreboard)
158 solenoid right turn forward (electronic scoreboard)
159 solenoid left turn forward (electronic scoreboard)
160 Relay working equipment paver
161 Sensor brake (running) pedal
162 Steering wheel sensor
163 steering angle sensor
164 Injector activation pressure sensor
167 alternator charging voltage sensor
168 Electrical system voltage
171 ambient air temperature sensor
172 air temperature sensor in the intake manifold
174 fuel temperature sensor
175 engine oil temperature sensor
177 transmission oil temperature sensor
190 Engine speed sensor
191 Gearbox output shaft speed sensor
248 Caterpillar data link
249 J1922 SAE (Society of Automotive Engineers) data link
250 J1708/J1587 SAE (Society of Automotive Engineers) data link
252 Calibration block
253 Personal control unit chip
254 Electronic control unit
256 Map of the adjusting characteristics of the engine
257 Detonation Level
258 crank angle sensor
259 Programmable fuel injection timing
260 Exhaust oxygen sensor (lambda)
261 Calibration of fuel injection timing
262 Sensor supply circuit 5 V
263 Power supply circuit of digital sensors (8 or 12 V)
264 Pedal to reduce speed
265 User Stop Engine Stop Input Circuit
266 Dry crank input circuit (no fuel injection)
267 Circuit input remote command signal protective shutdown of the engine
268 Programmed parameter error
269 Sensor supply circuit
270 Code for computerized monitoring system (CMS) cable
271 Audible alarm
272 Turbo boost sensor
273 pressure sensor at the outlet of the turbocharger
274 Atmospheric pressure sensor
275 pressure sensor at the inlet of the right turbocharger
276 pressure sensor at the inlet of the left turbocharger
277 Injection timing calibration sensor
278 Indicator light for turning on the automatic engine speed control (AESC)
279 coolant temperature sensor charge air cooler in the front section
280 temperature reducer sensor
281 Indicator light for checking the engine
282 Indicator light exceeding the permissible engine speed
283 Clogged air filter indicator light
284 EMS enable signal (electronic monitoring system) (engine operation signal)
285 Coolant overheat indicator light engine
286 low oil pressure indicator light
287 Low current digital output 7
288 Low current digital output 8
289 Fuel pressure sensor - in front of the fuel filter
290 Pressure sensor in the engine cooling fan drive pump
291 engine cooling fan solenoid
292 hydraulic oil cooling fan electromagnet
293 Power analog output 3
294 Power analog output 4
295 High Power Hydraulic Excavator Control Unit
296 transmission control unit
297 All-wheel drive system
298 Service brake pedal contact sensor
299 Gearshift lever position sensor
300 Primary windings of ignition coils
301 Primary winding of the ignition coil 1
302 Primary winding of the ignition coil 2
303 Primary winding of the ignition coil 3
304 Primary winding of the ignition coil 4
305 Primary winding of the ignition coil 5
306 Primary winding of the ignition coil 6
307 Primary winding of the ignition coil 7
308 Primary winding of the ignition coil 8
309 Primary winding of the ignition coil 9
310 Primary winding of the ignition coil 10
311 Primary winding of the ignition coil 11
312 Primary winding of the ignition coil 12
313 Primary winding of the ignition coil 13
314 Primary winding of the ignition coil 14
315 Primary winding of the ignition coil 15
316 Primary winding of the ignition coil 16
317 load sensor
318 Right knock sensor
319 Left knock sensor
320 Speed sensor / injection torque
321 Key switch reset / confirmation of the diagnostic message
322 Engine stop relay
323 Engine stop indicator light
324 Alarm lamp
325 Detonation caused by the ignition system
326 Detonation system
327 Wrong number of knock sensors
328 Wrong number of engine cylinders
329 Communication link error
330 Propane contact sensor input
331 ignition switch
332 Keyboard switch
333 switch alarm
334 Reserve output
335 scraper bucket auger electromagnet
336 Engine control switch
337 Remote emergency stop switch
338 Relay pump prelubrication engine
339 contact pressure sensor pre-engine lubrication
340 air cutoff solenoid
341 electromagnet 4 heating distributor of the hydraulic system
342 Auxiliary engine speed sensor
343 Nozzle injection neutralizer nitrogen oxides in the exhaust gases
344 Relay pump injection neutralizer nitrogen oxides in the exhaust gases
345 pressure sensor of the injection system of the neutralizer of nitrogen oxides in the exhaust gases
346 Relay system for stabilizing the working tool when driving
347 electromagnet for regulating the supply (displacement) of the hydraulic motor of the hydrostatic gearbox
348 Transmission lock switch
349 transmission timing solenoid
350 Lift rod position sensor
351 swash rod position sensor
352 Lift lever sensor (in the cab)
353 Swashplate sensor (in cab)
354 solenoid 1 lift
355 electromagnet 1 lowering
356 electromagnet 1 unloading
357 solenoid 1 return
358 drive for pressurizing the control circuit of the hydraulic system of working equipment
359 solenoid fixing lift
360 Electromagnet lowering lock
361 Tilt fixing solenoid for loading
362 motor fan speed control electromagnet
363 The drive of the stabilization system of the working tool when driving
364 Pressure sensor in the piston cavity of the lifting cylinder
365 Limiter setting switch
366 Contact sensor semi-automatic excavation
367 Switch stabilization system of the work tool when driving
368 Switch automatic / manual transmission mode
369 Input from the gear indicator of the gearbox
370 boom floating electromagnet
371 horn electromagnet
372 bucket opening electromagnet (for front shovel excavator)
373 electromagnet for closing the bucket with unloading through the folding bottom (for an excavator with a front shovel)
374 brake electromagnet turning mechanism
375 brake electromagnet turning mechanism
376 Travel indicator
377 travel brake solenoid
378 solenoid automatic lubrication machine
379 Pressure sensor for automatic lubrication of the machine
380 contact pressure switch modulation gearbox
381 contact sensor neutral position of the lift lever (in the cab)
382 Hitch lever position sensor
383 Hitch position sensor
384 Traction switch
385 Contact sensor neutral position of the tilt lever (in the cab)
386 hitch lift solenoid
387 solenoid lowering hitch
388 Return line of the solenoid hitch
389 contact sensor neutral position of the auxiliary lever
390 oil flow control solenoid through the forward hydraulic motor
391 solenoid control oil flow through the reverse motor
392 oil supply solenoid
393 front wheel drive electromagnet
394 solenoid control oil flow through the drive motor
395 solenoid switching pressure in the front wheel drive
396 indicator light all-wheel drive (AWD)
397 contact pressure sensor supply pump
398 Pressure sensor in the front wheel drive
399 Sensor impact lever all-wheel drive (AWD)
400 Secondary windings of ignition coils
401 Secondary winding of the ignition coil 1
402 Secondary winding of the ignition coil 2
403 Secondary winding of the ignition coil 3
404 Secondary winding of the ignition coil 4
405 Secondary winding of the ignition coil 5
406 Secondary winding of the ignition coil 6
407 Secondary winding of the ignition coil 7
408 Secondary winding of the ignition coil 8
409 Secondary winding of the ignition coil 9
410 Secondary winding of the ignition coil 10
411 Secondary winding of the ignition coil 11
412 Secondary winding of the ignition coil 12
413 Secondary winding of the ignition coil 13
414 Secondary winding of the ignition coil 14
415 Secondary winding of the ignition coil 15
416 Secondary winding of the ignition coil 16
417 Relay interrupt return circuit of the electromagnet
418 indicator light / oil flow switch in the main steering hydraulic circuit
419 Relay motor reverse
420 auxiliary steering relay
421 Load control relay
422 Drive shaft speed sensor
423 Contact pressure sensor in the front brake accumulator
424 contact pressure sensor in the rear brake accumulator
425 Oil pressure sensor in the hydraulic circuit of the front brake
426 Oil pressure sensor in the hydraulic circuit of the rear brake
427 front axle oil temperature sensor
428 rear axle oil temperature sensor
429 Oil pressure sensor main steering pump
430 Oil pressure sensor in the control circuit of the steering system
431 contact sensor low oil level in the steering tank
432 Contact differential pressure sensor on the oil filter of the steering system
433 contact differential pressure sensor on the hydraulic oil filter
434 Oil pressure sensor in the hydraulic control circuit
435 Oil level sensor in the hydraulic tank
436 Oil pressure sensor in the torque converter
437 contact pressure sensor oil filter hydraulic power transmission
438 solenoid 1 heating distributor hydraulic
439 solenoid 2 heating distributor hydraulic
440 solenoid 3 heating distributor hydraulic
441 Relay electronic speed controller
442 generator failure relay
443 Scroll interrupt relay
444 Electric starter relay
445 Work relay
446 Relay air engine shutdown
447 Fuel control relay
448 Backup relay
449 Switch manual rotation grip
450 Switch for manual opening and closing of the jaws
451 solenoid for turning the gripper clockwise
452 electromagnet for turning the gripper counterclockwise
453 jaw opening electromagnet
454 jaw closing electromagnet
455 Jaw closure pressure sensor
456 Hydrax contact pressure sensor
457 brake oil temperature sensor
458 Pressure sensor in the rod end of the swash cylinder
459 Torque converter control unit
460 Fuel pressure sensor behind the fuel filter
461 Additional auxiliary brake solenoid
462 contact pressure sensor ohl.zhidk. at the engine inlet
463 Safety solenoid double action hydraulic circuit working equipment
464 Sensor location of the bucket tilt lever in the return position
465 Accelerator lever position sensor at maximum idle speed
466 Pedal position sensor left track tape
467 Pedal Position Sensor Right Track Tape
468 Service brake pedal position sensor
469 solenoid forward left track tape
470 reverse electromagnet left track tape
471 solenoid forward right track tape
472 reverse electromagnet right track tape
473 supply pressure sensor
474 Programmable relay control unit
475 Coordination unit with user equipment 1
476 Coordination unit with user equipment 2
477 Backup relay 1
478 Reserve relay 2
479 Backup relay 3
480 Backup relay 4
481 Backup relay 5
482 Backup relay 6
483 Backup relay 7
484 Reserve relay 8
485 motor fan reversal solenoid
486 Switch reversing fan motor
487 position sensor of the third lever
488 position sensor of the fourth arm
489 Switch for selecting modes of operation of working equipment
490 work equipment lock switch
491 electromagnet of the third mode forward
492 electromagnet of the third mode back
493 electromagnet of the fourth mode forward
494 electromagnet of the fourth mode back
495 solenoid fifth mode forward
496 electromagnet of the fifth mode back
497 solenoid tilt right
498 solenoid tilt left
499 solenoid oil pump variable displacement hydraulic system of working equipment
500 Electronic control unit
501 Prechamber cylinder 1
502 Pre-chamber cylinder 2
503 Prechamber cylinder 3
504 Prechamber cylinder 4
505 Prechamber cylinder 5
506 Prechamber cylinder 6
507 Pre-chamber cylinder 7
508 Prechamber cylinder 8
509 Prechamber cylinder 9
510 Pre-chamber cylinder 10
511 Pre-chamber cylinder 11
512 Prechamber cylinder 12
513 Prechamber cylinder 13
514 Prechamber cylinder 14
515 Pre-chamber cylinder 15
516 Pre-chamber cylinder 16
517 All-wheel drive switch
518 pressure control unit
519 Crankcase gas pressure
520 Transmission configuration code
521 fuel temperature sensor
522 fuel calorific value sensor
523 Sensor actual engine speed
524 Sensor required engine speed
525 damper actuator
526 Exhaust valve actuator
527 Potentiometer setting unevenness
528 Potentiometer for setting the maximum idle speed
529 Fuel correction factor
530 ION sensor
531 Switch idling / rated speed
532 Input signal protective shutdown of the engine
533 Automatic retarder control system
534 Parallel/common service input
535 exhaust temperature sensor
536 Sensor low oil level in the engine
537 Coolant level sensor. engine
538 right air filter resistance sensor
539 Resistance sensor left air filter
540 Controlled equipment input circuit
541 Differential oil pressure sensor (bridge)
542 Engine oil pressure sensor in front of the oil filter
543 Oil pressure sensor in the engine after the oil filter
544 Engine cooling fan speed sensor
545 Ether injection control relay
546 Current limit relay in the ether injection system
547 Indicator light for on-air launch system
548 indicator light accelerator lock
549 Accelerator lock switch
550 Signal from the oxygen concentration sensor to the electronic control unit (ECM)
551 Communication circuit of oxygen concentration sensor and oxygen concentration stabilizer
552 Oxygen concentration sensor calibration / current engine speed
553 Oxygen concentration sensor calibration / current signal of oxygen concentration
554 Oxygen concentration sensor calibration / no oxygen concentration signal
555 Oxygen concentration sensor calibration / oxygen concentration signal against interference
556 Oxygen set sensor
557 Oxygen deficiency sensor
558 Relay automatic lubrication
559 Relay floating boom
560 Data link error
561 rear engine accelerator lock solenoid
562 Second generation electronic control system
563 No signal required speed
564 Interference in the signal of the required speed
565 Emergency stop of the engine due to the absence of a signal of the required speed
566 Erroneous operation of an emergency stop of the engine
567 indicator light standby electronic control unit (ECM)
568 Indicator light for switching on the backup electronic control unit (ECM)
569 oil injection solenoid
570 Out of temperature sensor readings outside the set range
571 solenoid drive forward elevator
572 solenoid drive reverse elevator
573 Jog pedal position sensor
574 grip lock solenoid
575 Elevator lever position sensor
576 Heinzmann drive
577 Heinzmann drive ratio
578 Heinzmann drive offset
579 Pulsating signal of the main electronic control unit (ECM)
580 Switch pressure sensor under load
581 solenoid switching under load
582 contact sensor differential pressure on the air filter
583 boom lift electromagnet
584 contact sensor low oil pressure in the engine
585 Sensor No. 1 speed of the output shaft of the gearbox
586 Rotary switch engine speed
587 position sensor engine speed controller
588 Display control system
589 Switch travel / digging
590 Engine control unit
591 Electrically erasable RAM (read-only)
592 lift solenoid 2
593 lowering solenoid 2
594 return solenoid 2
595 unloading solenoid 2
596 Electronic control unit working equipment
597 Discharge pressure sensor hydraulic pump
598 speed control solenoid
599 Computerized Control System (CMS)
600 hydraulic oil temperature sensor
601 brake air pressure sensor
602 Contact pressure sensor P2 gearbox
603 torque converter impeller clutch pressure sensor
604 Auto shift, lock switch
605 Wheel speed sensor 1
606 Wheel speed sensor 2
607 Wheel speed sensor 3
608 Wheel speed sensor 4
609 electromagnet 1 wheel brake
610 electromagnet 2 wheel brakes
611 solenoid 3 wheel brake
612 solenoid 4 wheel brake
613 front brake solenoid control circuit
614 rear brake control solenoid
615 The angle sensor of the semi-frames of the vehicle with articulation
616 System check mode switch
617 Inlet air heater relay in the intake manifold
618 Contact sensor left auxiliary brake
619 Contact sensor right auxiliary brake
620 Switch towing mode
621 downshift switch
622 Upshift switch
623 Direction switch
624 Transmission neutral contact sensor
626 Steering / transmission lock switch
627 Parking brake contact pressure sensor
628 Fast shift switch
629 converter sensor
631 solenoid clutch 1 gearbox
632 clutch solenoid 2 gearboxes
633 clutch electromagnet 3 gearbox
634 clutch electromagnet 4 gearboxes
635 clutch electromagnet 5 gearbox
636 clutch electromagnet 6 gearbox
637 reverse signal
638 starter solenoid
639 1st gear indicator light
641 solenoid No. 1 gearbox
642 solenoid No. 2 gearbox
643 solenoid No. 3 gearbox
644 solenoid №4 gearbox
645 solenoid №5 gearbox
646 solenoid №6 gearbox
647 electromagnet No. 7 gearbox
648 solenoid №8 gearbox
650 cable code
653 Electronic control unit
654 right trailer brake oil temperature sensor
655 oil temperature sensor of the left trailer brake
656 temperature sensor at the inlet of the trailer brake oil cooler
657 temperature sensor at the outlet of the trailer brake oil cooler
658 Pressure sensor right hydraulic cylinder trailer suspension
659 pressure sensor of the left trailer suspension hydraulic cylinder
660 12th gear lever input circuit
661 13th gear lever input circuit
662 14th gear lever input circuit
663 15th gear lever input circuit
664 16th gear lever input circuit
665 17th gear lever input circuit
666 18th gear lever input circuit
667 19th gear lever input circuit
668 gear lever
669 speed sensor input shaft gearbox
670 Left pedal position sensor
671 speed sensor output shaft transmission
672 speed sensor at the output of the torque converter
673 Sensor II speed output shaft gearbox
674 Sensor I frequency of rotation of the intermediate shaft of the gearbox
675 Sensor II speed intermediate gear box
676 Position sensor of the left track band
677 position sensor of the right track band
678 torque converter impeller clutch electromagnet
679 solenoid torque converter lock-up clutch
680 Switch mode manual / automatic activation of the work tool when driving
681 parking brake solenoid
682 Indicator light parking brake
683 Parking brake alarm
684 Manual reverse gear switch
685 Maintenance identification code
686 Work shift identification code
687 Identification code of additional equipment
688 power control electromagnet
689 left brake solenoid
690 right brake solenoid
691 solenoid No. 1 gearbox
692 solenoid No. 2 gearbox
693 solenoid No. 3 gearbox
694 solenoid №4 gearbox
695 solenoid №5 gearbox
696 solenoid №6 gearbox
697 priority valve solenoid
698 electromagnet left side clutch
699 solenoid right side clutch
700 Transmission gear engaged sensor
701 Gearbox output shaft speed sensor
702 Gear lever position sensor (contact)
703 Trailer hatch position sensor
704 Service brake contact pressure sensor
705 Body lift lever position sensor (contact)
706 Sensor finding the body in a raised position
707 solenoid increase gears (gearboxes)
708 downshift solenoid (gearboxes)
709 solenoid clutch lock transmission
710 power solenoid automatic retarder control (ARC)
711 distribution solenoid automatic retarder control (ARC)
712 Indicator light of the automatic deceleration system
713 Switch mode of operation of the automatic retarder control system
714 contact pressure sensor automatic retarder control
715 contact retarder pressure sensor
716 electrical power sensor
717 Remote switch accelerator
718 Gearbox
719 traction control system (TCS) solenoid proportional valve
720 Steering resolver
721 service brake solenoid
722 auxiliary brake solenoid
723 Relay automatic flashing beacon
724 solenoid lifting lifting mechanism
725 solenoid lowering mode lifting mechanism
726 Right steering solenoid
727 Left steering electromagnet
728 Control signal in automatic / manual modes
729 External switch for automatic / manual operating modes (from ground level)
730 Automatic / manual switch (in cab)
731 PWM signal engine speed (rpm) (duty ratio)
732 electromagnet of exact turn of a platform
733 hydraulic oil cooler lock solenoid
734 Diverting electromagnet of the automatic lubrication system
735 heavy lift electromagnet
736 Control channel automatic engine speed controller (AESC)
737 Converter pedal position sensor
738 Ripper position sensor
739 Differential lock indicator light
740 differential lock solenoid
741 Indicator light torque converter
742 indicator light / service brake relay
743 Sensor turn track tape when moving forward (PWM)
744 Sensor for turning the track tape when moving backward (PWM)
745 Speed control lever sensor (PWM)
746 Contact sensor rotor control system (PWM)
747 Steering mode contact sensor (PWM)
748 contact sensor door rotor
749 Recoil sensor
750 Manual rear wheel control mode switch
751 Water spray switch
752 brake electromagnet / belt tension rotor
753 solenoid service brake rotor
754 rotor clutch electromagnet
755 Water Spray Relay
756 rotor clutch oil temperature sensor (PWM)
757 rotor clutch oil pressure sensor (PWM)
758 Travel hydraulic oil pressure sensor (PWM)
759 Indicator light for low engine oil
760 Engine oil filter clogging indicator light
761 Fuel filter clogging indicator light
762 Contact temperature sensor gearbox oil
763 solenoid trenching mode
764 Transmission indicator light
765 Pressure sensor in the piston cavity of the swash cylinder
766 Pressure sensor in the differential lubrication system (bridge)
767 Oil pressure sensor pump variable displacement hydraulic circuit working equipment
768 Data link RS-485
769 Rod End Pressure Sensor Lift Cylinder
770 Caterpillar data link 2
771 Blind relay
772 Block control of the composition of the combustible mixture to prevent detonation
773 sensor control lever lifting mechanism
774 auxiliary accelerator pedal position sensor
775 Relay for heating the valve
776 control unit navigation system
777 steering angle sensor auxiliary steering system
778 Auxiliary air pressure sensor
779 cabin air temperature sensor
780 Autonomous Start Switch Relay
781 Lighting relay
782 indicator light engine stop external switch (from ground level)
783 indicator light speed stabilization mode
784 Engine vibration sensor
785 coolant temperature sensor in the engine cooling circuit
786 Coolant pressure sensor. in the engine cooling circuit
787 Coolant level sensor. in the engine cooling radiator
788 Engine retarder mode switch
789 pressure sensor main control circuit
790 Pressure sensor at the outlet of the swing drive pump
791 Jake Brake brake setting electromagnet to weak / strong braking state
792 Jake Brake brake setting electromagnet to medium / high braking state
793 contact pressure sensor hydraulic circuit of the main steering system
794 contact pressure sensor of the hydraulic circuit of the auxiliary steering system
795 Intermediate relay auxiliary steering system
796 solenoid high speed differential cooling fan (bridge)
798 General alarm output
799 Service tool
800 Main unit of the basic information processing system (VIMS)
801 Coordination unit (interface unit) 1 basic information processing system (VIMS)
802 Matching unit 2 of the VIMS system
803 Matching unit 3 of the VIMS system
804 Matching unit 4 VIMS systems
805 Matching unit 5 of the VIMS system
806 Matching unit 6 of the VIMS system
807 Matching unit 7 of the VIMS system
808 Matching unit 8 of the VIMS system
809 Speedometer/Tachometer 1
810 Speedometer/Tachometer 2
811 Dashboard 1
812 Dashboard 2
813 Dashboard 3
814 Dashboard 4
815 Message Center 1
816 Message center 2
817 Internal backup battery electronic control unit (ECM)
818 power mode switch
819 Data link to the display
820 Keyboard data channel
821 display power circuit
822 Liquid crystal display (LCD) backlight power circuit
823 Maintenance indicator light
824 Indicator light 1 (green) dump truck payload measurement system (TPMS)
825 Indicator light 2 (red) dump truck payload measurement system (TPMS)
826 torque converter oil temperature sensor
827 gas temperature sensor left exhaust manifold
828 right exhaust manifold gas temperature sensor
829 coolant temperature sensor rear section of the charge air cooler
830 front brake oil temperature sensor
831 Indicator of metal particles in the left final drive
832 Indicator of metal particles in the right final drive
833 rear brake oil temperature sensor
834 Indicator of metal particles in the differential (bridge)
835 differential oil temperature sensor (bridge)
836 oil temperature sensor left final drive
837 right final drive oil temperature sensor
838 pressure sensor left front suspension cylinder
839 pressure sensor right front suspension cylinder
840 Pressure sensor left rear suspension cylinder
841 pressure sensor right rear suspension cylinder
842 Indicator of metal particles of the left front working equipment
843 Indicator of metal particles of the right front working equipment
844 Indicator of metal particles in the left pump of the turning mechanism
845 Indicator of metal particles in the left hydraulic motor of the platform turn mechanism
846 Indicator of metal particles in the right hydraulic motor of the platform turn mechanism
847 Indicator of metal particles of the left rear work tool
848 Indicator of metal particles of the right rear work tool
849 Air pressure sensor in the pneumatic system
850 Metal particle indicator in gearbox
851 pressure sensor reducer
852 brake oil temperature sensor (right front)
853 brake oil temperature sensor (left front)
854 brake oil temperature sensor (right rear)
855 brake oil temperature sensor (left rear)
856 Slope sensor unit 1
857 Slope sensor unit 2
858 Generator circuit breaker short circuit
859 generator power relay
860 pump drive oil temperature sensor
861 Engine maintenance indicator light
862 pressure sensor P1 gearbox
863 pressure sensor P2 transmission
864 Oil pressure sensor variable displacement hydraulic pump working equipment
865 Engine Exhaust Temperature Indicator Light
866 Signal output proportional to load
867 motor retarder solenoid
868 Light indicator mode automatic gearshift
869 Sensor extension of the rod of the right lifting cylinder
870 Sensor extension of the rod of the left lifting cylinder
871 tilt sensor
872 Step ratio sensor
873 Pressure sensor oil pump circuit warp
874 Blade control mode switch
875 switch mode manual blade control
876 switch start quick unloading
877 Blade return sensor
878 rotary switch blade load selection
879 Sensor angle of attack ripper
880 Ripper position sensor (raised / lowered)
881 Switch automatic lift ripper
882 electromagnet of blocking of the working equipment
883 quick release solenoid
884 Stepping electromagnet
885 solenoid RV ripper valve
886 ripper penetration electromagnet
887 ripper extraction solenoid
888 ripper lowering solenoid
889 ripper lift solenoid
890 Telemetric Data Link
900 Left lift solenoid
901 Left lowering solenoid
902 Right lift solenoid
903 Right electromagnet lowering
904 rear lift solenoid
905 Rear lowering solenoid
906 Left slope sensor
907 Right slope sensor
908 blade angle sensor
909 Display 1 slope slope
910 Display 2 slope slope
911 Display 3 slope slope
912 Display 4 slope slope
913 Display 5 slope steepness
914 Display 6 slope slope
915 Light indicators of the direction of the slope from the left sensor
916 Light indicator output on a given slope from the left slope sensor
917 Lamps indicating the direction of the slope from the right sensor
918 Light indicator output on a given slope from the right slope sensor
919 Beep inconsistency slope slope left
920 Beep mismatch steepness of the slope on the right
921 Beep mismatch steepness of the slope
922 Automatic stop sensor in dangerous proximity
923 Height proximity sensor
924 Electronic control unit burner operation
925 Light indicator of the burner operating mode
926 Burner mode switch
927 Relay fuel pump burner
928 Relay spark plug burner left expander
929 Fan motor left expander
930 Fuel valve solenoid left expander
931 Manual burner switch left expander
932 Relay left main glow plug
933 Left main fan motor
934 Left main fuel valve
935 Manual switch left main burner
936 Relay spark plug burner right expander
937 Fan motor right expander
938 fuel valve right expander
939 Manual burner switch right expander
940 Relay right main glow plug
941 right main fan motor
942 Right main fuel valve
943 Automation switch right main burner
944 Conveyor speed switch
945 Conveyor mode switch
946 conveyor speed control solenoid
947 overdrive solenoid
948 gear shifter
949 solenoid power control travel motor
950 Dial speed sensor
951 rotor clutch oil pressure sensor
952 Rotor depth mode switch
953 Switch manual control depth of the rotor
954 Rotor lift lock switch
955 Rotor depth sensor
956 rotor lift solenoid
957 solenoid lowering the rotor
958 Rotary gear switch
959 rotor speed sensor
960 1st rotor clutch solenoid
961 solenoid clutch 2nd gear rotor
962 solenoid clutch 3rd gear rotor
963 Slope control unit
964 Double power mode selection signal output
965 Automatic dig switch
966 Traction control system indicator light (TCS)
967 Machine use conditions
968 indicator light transmission lock
969 front axle differential lock solenoid
970 central/rear axle differential lock solenoid
971 intermediate differential lock solenoid
972 Switch mode left auger
973 Switch mode of operation of the left conveyor
974 Switch mode of operation of the left feed mechanism
975 Rotary switch speeds of the left conveyor
976 paddle material height sensor in the left auger
977 Ultrasonic material height sensor in the left auger
978 Rotary material height adjuster in the left auger
979 electromagnet of the left pump of the material control system
980 Bypass solenoid left conveyor
981 left auger reverse electromagnet
982 Bypass electromagnet left auger
983 left auger rotation sensor
984 indicator light for diagnosing the material supply control system
985 control unit material feed paver
986 Switch mode right auger
987 Mode switch right conveyor
988 Switch mode of operation of the right feed mechanism
989 right conveyor speed switch
990 paddle material height sensor in the right auger
991 Ultrasonic material height sensor in the right auger
992 Rotary material height adjuster in the right auger
993 electromagnet of the right pump of the material control system
994 Bypass solenoid right conveyor
995 solenoid reverse right auger
996 Bypass solenoid right auger
997 right auger rotation sensor
998 traction solenoid
999 Regulator setting the maximum speed
1011 solenoid low speed differential cooling fan (bridge)
1012 front brake solenoid
1013 Proportional front brake solenoid
1014 front brake oil supply solenoid
1015 rear brake solenoid
1016 Proportional rear brake solenoid
1017 rear brake oil supply solenoid
1018 Steering resolver angle sensor
1019 angle sensor auxiliary steering resolver
1020 Front brake cooling filter sensor
1021 Rear brake cooling filter sensor
1022 Grease level sensor in the automatic lubrication tank
1023 Hydraulic system pressure gauge
1024 Gauge pressure gauge right steering pump
1025 Gauge pressure gauge left steering pump
1026 Oil return filter sensor from the steering system to the hydraulic tank
1027 Power supply 5
1028 Power supply 1
1029 Power supply unit 2
1030 Power supply 3
1031 Radio power supply 14 V DC
1032 Main power supply 14 V DC
1033 Keyboard power supply 5 V DC
1034 Manual dump dump switch
1035 Satellite navigation system (GPS) receiver
1036 Function keys
1037 Display unit
1038 analog output circuit speed controller settings
1039 Pulse-width signal output circuit speed controller settings
1040 Integrated combustion cleanliness control module (ICSM) 1
1041 Integrated Combustion Cleanliness Control Module (ICSM) 2
1042 Integrated Temperature Control Module (ITSM)
1043 The ignition signal of the combustible mixture in cylinder 1
1044 The ignition signal of the combustible mixture in all cylinders
1045 power train oil temperature sensor
1046 Power transmission oil filter clogged contact sensor
1047 skew electromagnet with one hydraulic cylinder
1048 Output signal 1 from the control source
1049 Output signal 2 from the control source
1050 Power supply 4
1051 Auxiliary power supply 14 V DC
1052 Backlight assembly
1053 temperature sensor drain oil left hydraulic oil pump
1054 temperature sensor drain oil central hydraulic oil pump
1055 temperature sensor drain oil right hydraulic oil pump
1057 Transmission / capture control unit
1058 hoist floating position electromagnet
1059 contact pressure sensor control circuit hydraulic lifting equipment
1060 contact pressure sensor control circuit of the hydraulic lowering of the working equipment
1061 Contact pressure sensor control circuit hydraulic return bucket
1062 contact pressure sensor control circuit hydraulic unloading bucket
1063 Automatic dig switch
1064 Indicator light for enabling automatic digging
1065 Machine remote control unit
1066 Automatic dig mode indicator light
1067 Automatic dig beep
1068 Beacon mode of automatic digging
1069 Work tool lifting signal
1070 signal lowering the working tool
1071 Bucket return signal
1072 Bucket unloading signal
1073 Display system for displaying basic information (VIDS)
1074 oil regeneration valve solenoid
1075 oil filling valve solenoid
1076 knock sensor A
1077 knock sensor B
1078 knock sensor C
1079 knock sensor D
1080 knock sensor E
1081 knock sensor F
1082 knock sensor G
1083 knock sensor H
1084 knock sensor I
1085 knock sensor J
1086 Sensitive element of the oxygen concentration sensor
1087 Buffer block oxygen concentration sensor
1088 oxygen concentration sensor supply circuit
1089 Data analysis block
1101 Fuel mixture combustion sensor in cylinder 1
1102 Fuel mixture combustion sensor in cylinder 2
1103 Combustible mixture combustion sensor in cylinder 3
1104 Combustible mixture combustion sensor in cylinder 4
1105 Fuel mixture combustion sensor in cylinder 5
1106 Fuel mixture combustion sensor in cylinder 6
1107 Combustible mixture combustion sensor in cylinder 7
1108 Combustible mixture combustion sensor in cylinder 8
1109 Combustion sensor of the combustible mixture in cylinder 9
1110 Fuel mixture combustion sensor in cylinder 10
1111 Fuel mixture combustion sensor in cylinder 11
1112 Fuel mixture combustion sensor in cylinder 12
1113 Combustible mixture combustion sensor in cylinder 13
1114 Fuel mixture combustion sensor in cylinder 14
1115 Combustion sensor of the combustible mixture in cylinder 15
1116 Combustion sensor of the combustible mixture in cylinder 16
1117 separator electromagnet
1118 solenoid drain flow in the neutral circuit
1119 boom lock solenoid
1120 handle lock solenoid
1121 solenoid high pressure front system
1122 rear system high pressure solenoid
1123 solenoid setting the frequency of hammer blows
1124 electromagnet anti-theft system
1125 Sensor front / rear position of the left arm
1126 Sensor left / right position of the left lever
1127 Sensor front / rear position of the right arm
1128 Sensor left / right position of the right lever
1129 forward pedal position sensor
1130 Attachment Pedal Position Sensor
1131 Button switch 1 joystick
1132 Button switch 4 joysticks
1133 Pressure sensor (load dependent) front main oil pump
1134 Pressure sensor (load dependent) rear main oil pump
1135 Pressure sensor on the drain from the crankcase of the front oil pump
1136 pressure sensor on the drain from the crankcase of the rear oil pump
1137 Pressure sensor on the drain from the crankcase of the oil pump of the hydraulic system of rotation
1138 solenoid retracting the rod of the boom hydraulic cylinder
1139 electromagnet extension of the rod of the hydraulic cylinder of the handle
1140 electromagnet retracting the rod of the hydraulic cylinder of the handle
1141 electromagnet extension of the bucket cylinder rod
1142 solenoid retracting the bucket hydraulic cylinder
1143 solenoid turning mechanism to the right
1144 electromagnet turning left
1145 solenoid extension / turn clockwise mounted implements
1146 solenoid retract / turn counterclockwise attachment
1147 solenoid circuit medium pressure 1-A
1148 solenoid circuit medium pressure 1-B
1149 solenoid check / modulating valve lowering the boom
1150 swing solenoid oil pump swashplate
1151 Switch pressure sensor under load front pump
1152 Switch pressure sensor under load rear pump
1153 Front pump pressure reserve sensor
1154 rear pump pressure sensor
1155 electromagnet of the front switching pressure supply pump under load
1156 electromagnet of the rear pump providing switching pressure under load
1157 front pump pressure solenoid
1158 rear pump pressure solenoid
1159 solenoid check / modulating valve lowering the handle
1160 Hydrolock electromagnet
1161 pressure sensor front hydraulic pump
1162 pressure sensor rear hydraulic pump
1163 Left electromagnet movement back
1164 Right electromagnet movement back
1165 Right forward electromagnet
1166 Left forward electromagnet
1167 Electric generator protection circuit breaker (EPG)
1168 Dead bus sensor
1169 ATB sensor (AC transformer unit)
1170 Sensor BTB (transformer busbar)
1171 Switch mode pump variable displacement hydraulic circuit working equipment
1172 Switch pump variable displacement hydraulic circuit working equipment
1173 hoist damping solenoid
1174 Relay enable lifting mechanism
1175 body position sensor
1176 signal output to turn off the engine
1177 Sensor fuel level converter
1178 pressure sensor overload warning system machine
1179 ES2000 translator module
1180 solenoid 1 auxiliary hydraulic system
1181 solenoid 2 auxiliary hydraulic system
1182 solenoid 1 high capacity
1183 solenoid 2 high capacity
1184 Power auxiliary hydraulic solenoid valves
1185 Power supply for high capacity solenoid valves
1186 High flow mode switch
1187 flow continuity sensor
1188 Manual override switch
1189 Auxiliary hydraulic lever
1190 Armrest/seat adjustment buttons
1191 Main valve actuator rotation mechanism
1192 Implement main valve
1193 electromagnet extension of the boom hydraulic cylinder
1194 The main unit of the machine information display system (MIDS)
1195 Contact sensor clogged hydraulic filter
1196 Fan filter clogging contact sensor
1197 blade lowering solenoid
1198 blade lift electromagnet
1199 Main unit of the basic information display system (VIDS)
1200 Additional filter system
1201 Thermocouple 1
1202 Thermocouple #2
1203 Thermocouple #3
1204 Thermocouple #4
1205 Thermocouple #5
1206 Thermocouple #6
1207 Thermocouple #7
1208 Thermocouple #8
1209 Thermocouple #9
1210 Thermocouple #10
1211 Thermocouple #11
1212 Thermocouple #12
1213 Thermocouple #13
1214 Thermocouple #14
1215 Thermocouple #15
1216 Thermocouple #16
1217 Thermocouple #17
1218 Thermocouple #18
1219 Thermocouple #19
1220 Thermocouple #20
1221 Thermocouple #21
1222 Thermocouple #22
1223 Thermocouple #23
1224 Thermocouple #24
1225 Oil pressure sensor left rear parking brake
1226 Oil pressure sensor right rear parking brake
1227 Retarder lever
1228 contact sensor enable auxiliary hydraulic system
1229 speed sensor brake cooling pump
1230 brake solenoid pump drive
1231 Bypass solenoid brake circuit
1232 Bypass electromagnet of the rear differential lubrication system
1233 Transmission lock pressure sensor No. 1
1234 Transmission lock pressure sensor No. 2
1235 transmission lock solenoid
1236 Light indicator raised position of the body
1237 Bypass electromagnet No. 1 pump lifting mechanism
1238 Bypass electromagnet No. 2 pump lifting mechanism
1239 electromagnet of the line tank-distributor of the piston circuit of the lifting mechanism
1240 electromagnet of the main tank-hydraulic distributor of the rod circuit of the lifting mechanism
1241 solenoid line pump-distributor of the piston circuit of the lifting mechanism
1242 solenoid line pump-distributor of the rod circuit of the lifting mechanism
1243 solenoid enable the control circuit of the lifting mechanism
1244 Safety solenoid second stage gearbox
1245 Pressure relief relay from the accumulator
1246 pressure sensor piston chamber hydraulic cylinder lifting mechanism
1247 Pressure sensor of the rod chamber of the hydraulic cylinder of the lifting mechanism
1248 retarder solenoid
1249 auxiliary accelerator pedal position sensor
1266 Diagnostic mode indicator light
1267 Low coolant level indicator light.
1268 Maintenance indicator light
1269 contact pressure sensor service brake operator
1270 temperature sensor at the inlet of the turbocharger
1271 Differential lubrication pressure sensor (bevel gear)
1272 contact sensor pressure accumulator brake system
1273 Chassis control unit
1274 Machine operation signal
1275 bucket lift electromagnet
1276 bucket lowering electromagnet
1277 apron lift solenoid
1278 apron lowering solenoid
1279 solenoid movement of the ejector forward
1280 solenoid movement of the ejector back
1281 Bucket lever position sensor
1282 Apron Lever Position Sensor
1283 ejector lever position sensor
1284 Elevator speed change lever position sensor
1285 auger forward electromagnet
1286 auger movement electromagnet back
1287 elevator speed control solenoid
1288 Hitch Relay
1289 Depreciation relay hitch
1290 Apron swim mode switch
1291 Hitch switch
1292 Transmission lock contact sensor
1293 Switch depreciation hitch
1294 Ejector return indicator light
1295 Apron float indicator light
1296 Light indicator of work in tractor mode
1297 Light indicator of operation in scraper mode
1299 elevator enable solenoid
1300 electromagnet for changing the direction of movement of the elevator
1301 gas supply valve solenoid (GAV) to cylinder No. 1
1302 gas supply valve solenoid (GAV) to cylinder No. 2
1303 gas supply valve solenoid (GAV) to cylinder No. 3
1304 gas supply valve solenoid (GAV) to cylinder No. 4
1305 gas supply valve solenoid (GAV) to cylinder No. 5
1306 gas supply valve solenoid (GAV) to cylinder No. 6
1307 gas supply valve solenoid (GAV) to cylinder No. 7
1308 gas supply valve solenoid (GAV) to cylinder No. 8
1309 gas supply valve solenoid (GAV) to cylinder No. 9
13010 gas supply valve solenoid (GAV) to cylinder No. 10
1311 gas supply valve solenoid (GAV) to cylinder No. 11
1312 gas supply valve solenoid (GAV) to cylinder No. 12
1313 gas supply valve solenoid (GAV) to cylinder No. 13
1314 gas supply valve solenoid (GAV) to cylinder No. 14
1315 gas supply valve solenoid (GAV) to cylinder No. 15
1316 gas supply valve solenoid (GAV) to cylinder No. 16
1317 gas supply valve solenoid (GAV) to cylinder No. 17
1318 gas supply valve solenoid (GAV) to cylinder No. 18
1319 gas supply valve solenoid (GAV) to cylinder No. 19
1320 gas supply valve solenoid (GAV) to cylinder No. 20
1321 End sensor limiter slip auger
1322 Auger reverse switch
1323 auger slip limiter electromagnet
1326 Location code of the electronic control unit (ECM)
1327 Left brake pedal position sensor
1328 Right brake pedal position sensor
1329 Contact sensor left brake pedal
1330 Contact sensor right brake pedal
1401 transmission solenoid No. 1
1402 solenoid transmission №2
1403 transmission solenoid No. 3
1404 transmission solenoid No. 4
1405 transmission solenoid No. 5
1406 transmission solenoid No. 6
1407 transmission solenoid No. 7
1408 transmission solenoid No. 8
1409 transmission solenoid No. 9
1410 transmission solenoid No. 10
1411 transmission solenoid No. 11
1412 transmission solenoid No. 12
1413 transmission solenoid No. 13
1414 transmission solenoid No. 14
1415 transmission solenoid No. 15
1416 transmission solenoid No. 16
1417 transmission solenoid No. 17
1418 transmission solenoid No. 18
1419 transmission solenoid No. 19
1420 transmission solenoid No. 20